澳门新萄京赌场网址【澳门葡萄京官方网站】

当前位置:澳门新萄京赌场网址-资讯中心 > 资讯中心

山东通风管道?定时清洗的必要性?

发布人:   发布时间:2020-04-08 11:48:44

随着使用时间的增加,通风管道会积累大量的杂质。这些杂质会在管道中储存很长时间,在操作过程中会加速油的凝结。温度转换过高,会对气动阀、液压等元件造成损坏,并对正常运行有很大影响。因此,定期对通风管道设备进行清洗是非常必要的。

  With the increase of service time, a large amount of impurities will accumulate in the ventilation pipe. These impurities will be stored in the pipeline for a long time, which will accelerate the oil condensation during operation. Too high temperature conversion will damage the pneumatic valve, hydraulic and other components, and have a great impact on normal operation. Therefore, it is very necessary to clean the ventilation equipment regularly.

  (1)风道与风机连接时,进、出口均应安装软接头。软接头的截面尺寸应与风机进出口截面尺寸一致。软管接头可以由帆布、人造皮革和其他材料制成。软管长度不应小于200,并应适当拧紧。软管可以缓冲风扇的振动。

  (1) When the air duct is connected with the fan, soft joints shall be installed at the inlet and outlet. The section size of soft joint shall be consistent with that of fan inlet and outlet. Hose connections can be made of canvas, artificial leather, and other materials. The hose length shall not be less than 200 and shall be properly tightened. The hose dampens the vibration of the fan.

  (2)风道连接除尘设备和加热设备时,设备安装完毕后,按理论映射图暂停预制。

  (2) When the air duct is connected with the dedusting equipment and the heating equipment, the prefabrication shall be suspended according to the theoretical map after the installation of the equipment.

  (3)安装通风管道时,在预制管道时应将进、出口打开。如果需要在安装结束时打开管道,则接口应紧密。

山东通风管道

  (3) When installing the ventilation pipe, the inlet and outlet shall be opened when prefabricating the pipe. If it is necessary to open the pipe at the end of installation, the interface shall be tight.

  (4)输送凝结水或含湿量大的气体时,水平管道应呈斜坡状,并在低处与排水管道连接。安装时,管道底部不应出现纵向接缝,底部接缝应悬挂密封处理。

  (4) When transporting condensed water or gas with large moisture content, the horizontal pipeline shall be sloped and connected with the drainage pipeline at the low place. During installation, there shall be no longitudinal joint at the bottom of the pipeline, and the bottom joint shall be suspended for sealing.

  (5)输送易燃易爆气体的钢板风道,应在风道连接法兰处安装跳线,并与静电地网连接。

  (5) For the steel plate air duct conveying inflammable and explosive gas, the jumper shall be installed at the connecting flange of the air duct and connected with the electrostatic ground grid.

  (6)水平风道高度大于4m时,安装人员应系好安全带。脚手架或活动支架上的板材应固定,板材的宽度应符合安全规范,脚手架上的设备人员应随身携带包袋,避免物品或钻头等物品掉落伤及。

  (6) When the height of horizontal air duct is more than 4m, the installation personnel shall fasten the safety belt. The plate on the scaffold or movable support shall be fixed, and the width of the plate shall conform to the safety specifications. The equipment personnel on the scaffold shall carry bags with them to avoid the falling of articles or drill bits and other articles.

  (7)双臂支撑在风道内就位后,横臂应伸直,不应更换双臂,双臂受力均匀。

  (7) After the double arms are supported in place in the air duct, the cross arms shall be extended, and the double arms shall not be replaced, and the force on the double arms shall be even.

  每三个月清洗一次,既保证了风管的正常运行,又延长了风管的使用寿命。

  Cleaning every three months not only ensures the normal operation of the air duct, but also extends the service life of the air duct.

  以上就是对山东通风管道的清理的必要性的详细先容,想要了解更多请点击官网

  The above is a detailed introduction to the necessity of cleaning the ventilation pipes in Shandong Province. For more information, please click


上一篇:【澳门葡萄京官方网站】流程的合理性?
下一篇:济南通风管道设计方案规范的重要性?

澳门新萄京赌场网址 关于大家 产品展示 资讯中心 工程案例 在线留言 联系大家

XML 地图 | Sitemap 地图